Aalborg Dfc26S-Van5-C5-3Ab-01-Ss, Dfc Thermal Mass Flow Controller

USD 1481.00

In stock

Aalborg, DFC26S-VAN5-C5-3AB-01-SS, DFC Thermal Mass Flow Controller Stainless Steel, Viton-A Seals, 1/4" Compression, No Display, +15 VDC, 0-5 VDC/ 0-5 VDC, RS485, Air 0-10 mL/Min, 14.7 psia Metering Pressure, 21.1 Deg C / 70 Deg F Temperature DFC digital mass flow controller Controller can be programmed for various control functions including flow set point, totalizer, stop totalizer, read totalizer, totalizer from preset flow, stop at preset total, auto zero, and more

A Wheatstone bridge design is used to monitor the temperature dependent resistance gradient on the sensor windings which is linearly proportional to the instantaneous rate of flow

Alarm conditions are reported via the digital interface or can activate the contact closure outputs

An on-board microprocessor and nonvolatile memory store all calibration factors and directly control a proportionating electromagnetic valve

Auto Tune The Auto Tune function allows the DFC to automatically optimize control response for the gas under actual process conditions

Auto Zero The DFC automatically nulls the sensor zero offset whenever the flow set point is below 2 of full scale

Balanced Power Supply The DFC operates on plusmn 15 VDC

Both flow conduits are designed to ensure laminar flows and therefore the ratio of their flow rates is constant

Contact Closure Programmable via the digital interface such that the relays can be made to switch when a specified event occurs e.g

Conversion Factors Conversion factors for up to 256 gases are stored in the DFC

Conversion factors may be applied to any of the ten gas calibrations via digital interface commands

Deviations from the set point are corrected by compensating valve adjustments, with PID algorithm thus maintaining the desired flow parameters with a high degree of accuracy

Digital interface commands are provided to Set the totalizer to Zero Start/Stop totalizing the flow Read the totalizer Start the totalizer at a preset flow Stop the flow at a preset total Multi-Gas Calibration The DFC is capable of storing primary calibration data for up to 10 gases

Engineering Units The flow set point, measured gas flow and associated totalizer data is scaled directly in engineering units via digital interface commands

Flow Alarms High and Low gas flow Alarm limits are programed using the digital interface

Interface The digital interface operates access to applicable internal data including Flow Set Point, Actual Flow, Zero Adjustments, and linearization Table Adjustments

Maximum power consumption is 13.5 watts at plusmn 15 VDC.

Principles of Operation Metered gases are divided into two laminar flow paths, one through the primary flow conduit, and the other through a capillary sensor tube

Programmable Flow Aalborg software supports programmable flow modes, allowing execution of custom programming of up to ten steps

Provisions are made to either disable, force or store the current auto zero via digital commands

Self Diagnostics Whenever power is first applied, the DFC runs a series of Self Diagnostic Tests to ensure that it is in optimum working condition

The current requirements for the positive and negative power supplies are balanced such that the current in the power supply common connection is minimized

The digital closed loop control system continuously compares the mass flow output with the selected flow rate

The following units of measure are supported of FS, mL/min, mL/hr, SCFM, SCFH, sL/min, sL/hr, lbs/hr, lbs/min, and one user defined unit of measure

The output of the Wheatstone bridge is converted to digital format with a 12 Bit ADC analog to digital converter

The resultant temperature differential is proportional to the change in resistance of the sensor windings

The total mass of gas is calculated by integrating the actual gas flow rate with respect to time

This feature allows the same DFC to be calibrated for multiple gases while maintaining the rated accuracy on each

To accommodate this feature the control valve must fully close under that condition

Totalizer The firmware for the DFC provides functions to register total gas quantity

Two precision temperature sensing windings on the sensor tube are heated, and when flow takes place, gas carries heat from the upstream to the downstream windings

Valve Override Means are provided to force the control valve fully open purge or fully closed via either the analog or digital interfaces

Various flow configurations include ramping, linearized increasing and decreasing modes

When a low or high flow alarm limit is exceeded or when the totalizer reaches a specified value

Related

Florence 4 Piece Outdoor Wicker

Florence 4 Piece Outdoor Wicker

Florence 4 Piece Outdoor Wicker Patio Furniture Set 04a in Wheat - TK Classics Florence-04A-Wheat Our Florence Collection creates a warm, inviting and durable seating area that compliments its surroundings

1323.99 USD

Ocean Pearl Area Rug

Ocean Pearl Area Rug

Ocean Pearl Area Rug - Nourison OCP02 OCP02 Feature With their soft and luminous hand-tufted pile, the area rugs of the Ocean Collection invite you to dip in your

3406.30 USD

Panama Jack Sanibel 6PC Sectional

Panama Jack Sanibel 6PC Sectional

Panama Jack Sanibel 6PC Sectional Set with Cushions With hand braided banana leaf fiber over solid rattan frames, the Panama Jack Sanibel collection has been uniquely designed to create furniture

2033.97 USD

44 in. Media Console in

44 in. Media Console in

Transitional style. One adjustable shelf. Burnished brass oval shaped hardware. Two sliding doors. Speaker screen and glass panel inserts. Overlapping diamond fretwork. Wire management on the back panel. Top center

675.00 USD

Modern Expressions Ottoman - Butler

Modern Expressions Ottoman - Butler

Modern Expressions Ottoman - Butler Specialty 4074260 This handsome ottoman is rustic yet transitional in style. Brass finished nail heads outline the polyester suede base, providing contrast to the

469.00 USD

Kobe 48 Flip Top

Kobe 48 Flip Top

Kobe 48 Flip Top Mobile Training Table in Mocha Walnut 2 'M' Stack Chairs in Black - Regency MKFT4824MW47BK Set up a meeting room in a flash

387.97 USD

Hide Outdoor Patio Swing Chair

Hide Outdoor Patio Swing Chair

Hide Outdoor Patio Swing Chair With Stand EEI-2273-GRY-RED Escape to an exotic island of serenity with the Hide Swing Chair. Made with a luxurious synthetic rattan weave and plush all-weather

504.59 USD

Caracole Modern Artisans Artisans Nightstand

Caracole Modern Artisans Artisans Nightstand

Shown in Dark Fumed Oak and Artisan Metal finish. The classic nightstand with a twist. Matte gold artisan metal twists to form an elegant base accentuating this sleek nightstand's

950.00 USD

GE Desal 1207352

GE Desal 1207352

The P-Series family of polyethersulfone ultrafiltration membrane elements are characterized by a molecular weight cut-off of 10, 000 and greater than 96 rejection of Cytochrome-C 13, 300 MW

714.14 USD

Accuform FRMCSA150XL10, Safety Sign

Accuform FRMCSA150XL10, Safety Sign

Accuform, FRMCSA150XL10, 14 x 10 Safety Sign Danger! Corrosive Materials Aluma-Lite Features Resists impacts, flexing, vandalism, corrosion, chemicals, abrasions, and more Material is 40

279.30 USD

Radwag PUE 5.19IR.E2R.S512, PUE 5

Radwag PUE 5.19IR.E2R.S512, PUE 5

Radwag, PUE 5.19IR.E2R.S512, PUE 5 Infrared Terminal Measuring Indicator with E2R Formulas, 4 GB RAM, 512 GB SSD for Scales PUE 5.19IR - infrared touch screen technology. Protection class IP65.

5971.00 USD

Zebra MC32N0-GL4HCHEIA, Gun EVM 1GHz

Zebra MC32N0-GL4HCHEIA, Gun EVM 1GHz

Zebra, MC32N0-GL4HCHEIA, MC32N0-G Gun EVM, 1GHz Processor, 1GB RAM/4GB ROM Zebra Evm, MC32n0-G, Wlan 802.11 A/B/G/N, 1ghz Processor, 1d Laser Se96x, Color-touch Display, 48 Key, High Capacity Battery, Ce 7.x

1473.78 USD

Xeltek CX1060-6004EGP, SOP54 Open Top

Xeltek CX1060-6004EGP, SOP54 Open Top

Xeltek, CX1060-6004EGP, SOP54 Open Top Socket Adapter for SuperPro 6004EGP

297.00 USD

Bellco Glass 5636-38500, 500 mL

Bellco Glass 5636-38500, 500 mL

Bellco Glass, 5636-38500, 500 mL Media Storage Bottle with 38 mm. Closure Features Borosilicate glass Type 1, Class A Supplied with a 38 mm deep skirt, rubber lined black

424.90 USD

Accuform SBMEQM048XL10, 14 x

Accuform SBMEQM048XL10, 14 x

Accuform, SBMEQM048XL10, 14 x 10 Spanish Bilingual Safety Sign Starts Automatically Aluma-Lite Features Resists impacts, flexing, vandalism, corrosion, chemicals, abrasions, and more Material is 40

279.30 USD

Xeltek CX1005-5004EGP, TSOP40 Cover Socket

Xeltek CX1005-5004EGP, TSOP40 Cover Socket

Xeltek, CX1005-5004EGP, TSOP40 Cover Socket Adapter for SuperPro 5004EGP

271.80 USD

Accuform SBMVTR503XL10, 18 Safety

Accuform SBMVTR503XL10, 18 Safety

Accuform, SBMVTR503XL10, 18 Bilingual Safety Sign Sound Horn Proceed with Caution Aluma-Lite Features Resists impacts, flexing, vandalism, corrosion, chemicals, abrasions, and more Material is 40

622.20 USD

Accuform MHSK596XF10, 10 x

Accuform MHSK596XF10, 10 x

Accuform, MHSK596XF10, 10 x 14 Safety Sign Eating And Drinking Permitted Only In The Lunchroom Dura-Fiberglass Features Image is printed on rigid fiberglass material with

264.80 USD

Accuform SHMCHL069VP10, 14 x

Accuform SHMCHL069VP10, 14 x

Accuform, SHMCHL069VP10, 14 x 20 OSHA Danger Safety Sign Flammable Plastic Features Manufactured with 50 Post-Consumer Recycled plastic and is recyclable ndash

246.20 USD

Diamond Vantage 2015EVWZX4-5, Zenesis V

Diamond Vantage 2015EVWZX4-5, Zenesis V

Diamond Vantage, 2015EVWZX4-5, Zenesis V 20 x 0.155 x 1 Segmented Blade, 12 mm Features The most advanced diamond pattern for fast cutting through hard, reinforced concrete

531.00 USD

Accuform MCHL007VA10, OSHA Danger Safety

Accuform MCHL007VA10, OSHA Danger Safety

Accuform, MCHL007VA10, 10 x 14 OSHA Danger Safety Sign Flammable Area ... Aluminum Legend Flammable Area - No Smoking Within 50 Ft. Features

219.50 USD

Isopure Water ISO-RO6UV

Isopure Water ISO-RO6UV

Provides the best protection for well water or city water. Use the same technology as most bottled water companies and produce your own bottled water in your kitchen. Removes over

239.99 USD